| From | Message |
MechanicMike
Dodge Dakota
JOIN HERE
11/08/2002
21:22:08
|
 Subject: Tapping Noise
IP: Logged
Message:
Got an 02 CC Sport 4.7l 5 speed with 2400 miles. Noticed for the first time last night while cold a slight ticking sound. It definitely wasn't the injectors, almost sounded like an out of adjusted valve or something. Anyone ever run into this? Any replies would be much appreciated.
|
Michael
DakotaEnthusiast
 
11/08/2002
21:29:24
|  RE: Tapping Noise
IP: Logged
Message:
Engine - Light Ticking Noise
NUMBER: 09-09-99
GROUP: Engine
DATE: Dec. 3,1999
SUBJECT:
Engine Ticking Noise
OVERVIEW:
This bulletin involves removing a portion of the insulation from the engine ground strap.
MODELS:
2000 (AN) Dakota
2000 (DN) Durango
NOTE: THIS BULLETIN APPLIES TO VEHICLES EQUIPPED WITH THE 4.7L ENGINE BUILT BEFORE NOVEMBER23, 1999 (MDH 1123XX).
SYMPTOM/CONDITION:
An engine ticking noise is heard coming from the engine compartment.
DIAGNOSIS:
With the hood and all doors closed, start the engine and listen for a ticking noise coming from the engine compartment. If a light ticking noise is heard coming from the engine compartment, perform the Repair Procedure.
REPAIR PROCEDURE:
THIS REPAIR IS COMPATIBLE WITH DAIMLERCHRYSLER~S MOBILE SERVICE PROGRAM AND IDOES NOT REQUIRE HOISTS OR OTHER FULL SERVICE FACILITY SPECIAL EQUIPMENT.
1. Remove the nut that secures the right side engine ground strap to the outer dash panel (Figure 1 and Figure 2) and detach the strap from the dash panel.
2. From the ground strap eyelet, measure back approximately two inches and carefully, strip back the two-inch section of insulation surrounding the wire.
3. Reattach the engine ground strap onto the dash panel. Tighten the attaching nut to 9 N.m (80 in. lbs.).
POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:Labor Operation No: 08-90-10-90 0.2 Hrs.
FAILURE CODE: AM - Authorization Modification
Shouldn't apply to your newer truck, this is from 99. But you never know. Some response is better than no response. Good Luck and hope this helps you out a little.
Michael
Z-Tube, R/T Rims, SSB Rear Disc Conversion, Alpine Head-Unit, Infinity Kappa Speakers, SilverStar Headlights, HO Cams & Intake installed.
Got H.O. ?
|
MechanicMike
Dodge Dakota
JOIN HERE
11/08/2002
21:39:49
| RE: Tapping Noise
IP: Logged
Message:
Thanks Mike Appreciate the info
|
BURT
Dodge Dakota
JOIN HERE
11/11/2002
11:56:59
| RE: Tapping Noise
IP: Logged
Message:
I have the same thing on my o2 4.7 tick's and tap's does not sound like ground strap it sound's internal I'm puzzled also.Only here it at idle and at a drive through.
|
Michael
DakotaEnthusiast
11/11/2002
22:03:47
| RE: Tapping Noise
IP: Logged
Message:
No Problem.
Michael
Z-Tube, R/T Rims, SSB Rear Disc Conversion, Alpine Head-Unit, Infinity Kappa Speakers, SilverStar Headlights, HO Cams & Intake installed.
Got H.O. ?
|
eallen
Dodge Dakota
JOIN HERE
11/11/2002
22:21:14
| RE: Tapping Noise
IP: Logged
Message:
I had what I thought was a ticking noise coming from the engine. I could hear it best right in front of the radiator. It actually turned out to be a chirp that the belt was making. The dealer replaced the belt and no more ticking! I know the difference between a chirp and a tick but this really sounded like a tick to me.
Anyway, it might be something to look at.
2001 QC 4X4 4.7L
|
INAHURY1
Dodge Dakota
JOIN HERE
11/26/2002
16:11:02
| RE: Tapping Noise
IP: Logged
Message:
My 02 4.7L does the same thing at idle. Just noticed it this morning and was looking on this site to see if anyone els had the same problem.
|
MONTI
Dodge Dakota
JOIN HERE
11/27/2002
11:50:42
| RE: Tapping Noise
IP: Logged
Message:
MY 02 ALSO DOES THIS AT IDLE AND CAN HERE IT AT A DRIVE THROUGH.TECH. SAY'S IT'S TORQUE CONV. AND FLEX PLATE THEY HAVE THEM ON ORDER.HAVE 8000 MILES ON IT. ANY ONE ELSE IN SAME BOAT? OR ARE THEY GUESSING????
|
Lab Rat
GenIII
11/27/2002
13:18:44
| RE: Tapping Noise
IP: Logged
Message:
SAme here, 02 QC 4.7. Drives me nuts!
Gibson Dual Sport, AirForce One air intake, Jet II, Jet TBS, 180 stat, IAT, TPS, no viscous fan, Lakewood traction bars, "Wilson" antenna ball...when are we gonna see some real parts??!!
|
2001rt
Dodge Dakota
JOIN HERE
11/27/2002
14:11:55
| RE: Tapping Noise
IP: Logged
Message:
I have the 5.9 R/T but I just got mine out of the shop yesterday for a ticking on the drivers side. I only heard it after the motor warmed up at idle and if you were next to a wall (like at a drive through) it was really loud. They replaced the lifters on the drivers side and the tick is gone.
|
| | P 1 |
|
Post a reply to this message:
Username Registration: Optional
All visitors are allowed to post messages
|
