Forums
Forum Tools
|
 |
22:41:11 - 12/19/2024
V6 Dakotas
| From | Message |
todd
Dodge Dakota
JOIN HERE
1/01/2008
14:05:10
|
 Subject: front differential oil leak
IP: Logged
Message:
hello,
I have a 99 V6 dakota with 5 speed (4wd). The front seal for the differential has been leaking for awhile and I need to replace it. Its the seal for the drive line. Has anyone had the same problem and have any tips to offer in replacing it? It doesn't look to tough but just checking if anyone has done this before.
|
dakota49
Dodge Dakota
JOIN HERE
1/02/2008
08:41:46
| RE: front differential oil leak
IP: Logged
Message:
todd, its the same as the rear axle. I'm not sure if they use a crush sleave or not on the 99, on my 88 it doesn't have a crush sleave.
When you say the "drive line" I assume you mean where the drive shaft from the transfer case goes to the drive axle.
If you have a manual go by what it says, if not, make sure you mark every thing the yoke, U joints, the bolt that holds the yoke on and the pinion shaft as well so everything will go back together as it came apart. Before you you remove the yoke, you will need to use an INCH POUND torque wrench and see how much torque it takes to turn the bolt/yoke. write the number down, then remove the bolt, washer, yoke, then the seal. Replace in the order of removel. and torque to spec. The spec for my 88 is 96Inch Pounds. after you torque the bolt, recheck the torque it takes to turn the bolt/yoke and it should be pretty close to the same as when you checked before you removed it. although most likely it will be a little tighter, that's common.
Good Luck
Dakota49
1988 3.9 4X4 5speed
|
todd
Dodge Dakota
JOIN HERE
1/09/2008
05:10:56
| RE: front differential oil leak
IP: Logged
Message:
Hey, thanks for the info.! I went an ordered the seal today so hopefully during spring break will have time to finally fix it.
|
| | P 1 |
|
Post a reply to this message:
Username Registration: Optional
All visitors are allowed to post messages
|
|
